lab

Propane Furnace Manifold Pressure

Propane Furnace Manifold Pressure. You have a gas supply problem between the tank and regulator. Lar listing of appropriate manufacturer’s kits for propane gas and/or high altitude installations.

Adjusting Pressure on Gas Manifold Appliance Video from www.appliancevideo.com

But its not considered a regulator. Oh, your calling the gas valve a regulator. Your main pressure may be dropping too low it looks like normally #55 orifices would be used.

However, The Max Pressure That The Manifold Pressure Can Be Adjusted Is About 9.6 Of Gas Pressure.

Pressure gauge) at either the gas valve inlet pressure boss. I just replaced the fuel valve on my propane furnace and when adjusting the outbound pressure i cannot get the measurement higher than 8.5wc. Manifold pressure is the gas pressure that the gas valve delivers to the burners, to supply the btu’s.

Turn Off Gas To Furnace At The Manual Gas Shutoff Valve.

There are numerous parts of a gas furnace that must be carefully synchronized and optimized in order for your heating to proceed efficiently. One of the most important considerations is the pressure of the incoming gas. It has a reg built into it.

Your Main Pressure May Be Dropping Too Low It Looks Like Normally #55 Orifices Would Be Used.

Make sure you check your supply pressure with the burner running. Connect a calibrated water manometer (or appropriate gas. Make sure you have a nice blue flame.

If Running On Slightly Lower Pressure It May Be Better Running On The #54'S.

The manifold pressure below 4500 feet. You have a gas supply problem between the tank and regulator. The service data indicates that first stage heating with blower on medium low the cfm is 971, temp rise is 58 at 0.1 static pressure.

The Manifold Pressure Can Be Adjusted By Turning The Regulator Clockwise To Increase Pressure And Counter Clockwise To Decrease.

Second stage is 1464 cfm, temp rise is 59 at 0.1 static pressure. Or the gas piping drip leg. In most cases, a gas furnace should have a manifold pressure of around 3.5 inches of water, or 3.5 wc for short.

Leave a Reply

Your email address will not be published. Required fields are marked *